The Coandă effect /ˈkwɑːndə/ is the tendency of a fluid jet to be attracted to a nearby surface. The principle was named afterRomanian aerodynamics pioneer Henri Coandă, who was the first to recognize the practical application of the phenomenon in aircraft development.
The lateral pressure which urges the flame of a candle towards the stream of air from a blowpipe is probably exactly similar to that pressure which eases the inflection of a current of air near an obstacle. Mark the dimple which a slender stream of air makes on the surface of water. Bring a convex body into contact with the side of the stream and the place of the dimple will immediately show the current is deflected towards the body; and if the body be at liberty to move in every direction it will be urged towards the current…
A hundred years later, Henri Coandă identified an application of the effect during experiments with his Coandă-1910 aircraft which mounted an unusual engine designed by Coandă. The motor-driven turbine pushed hot air rearward, and Coandă noticed that the airflow was attracted to nearby surfaces. He discussed this matter with leading aerodynamicist Theodore von Kármán who named it the Coandă effect. In 1934 Coandă obtained a patent in France for a “Method and apparatus for deviation of a fluid into another fluid”. The effect was described as the “Deviation of a plain jet of a fluid that penetrates another fluid in the vicinity of a convex wall.” This effect is most noticeable near a curved surface, where the air stream has to speed up near the convex side, and hence lose pressure. Natural molecular movement in the air tends to equalise the overall pressure, and pushes in free air, which joins the original jet along the same trajectory as the convex side of the surface. In turn, this generates lift against the convex surface.
ApplicationsThe Coandă effect is a result of entrainment of ambient fluid around the fluid jet. When a nearby wall does not allow the surrounding fluid to be pulled inwards towards the jet (i.e., to be entrained), the jet moves towards the wall instead. The fluid of the jet and the surrounding fluid should be essentially the same substance (a gas jet into a body of gas or a liquid jet into a body of liquid). In one application, a jet of air is blown over the upper surface of an airfoil, which can have a strong influence on the overall lift, especially at high angles of attack when the flow would otherwise separate (stall). See Blown flap.
The Coandă effect has important applications in various high-lift devices on aircraft, where air moving over the wing can be “bent down” towards the ground using flaps and a jet sheet blowing over the curved surface of the top of the wing. The bending of the flow results in aerodynamic lift. The flow from a high speed jet engine mounted in a pod over the wing produces increased lift by dramatically increasing the velocity gradient in the shear flow in the boundary layer. In this velocity gradient particles are blown away from the surface, thus lowering the pressure there. Closely following the work of Coandă on applications of his research, and in particular the work on his “Aerodina Lenticulară,” John Frost of Avro Canada also spent considerable time researching the effect, leading to a series of “inside out” hovercraft-like aircraft from which the air exited in a ring around the outside of the aircraft and was directed by being “attached” to a flap-like ring.
This is as opposed to a traditional hovercraft design, in which the air is blown into a central area, the plenum, and directed down with the use of a fabric “skirt”. Only one of Frost’s designs was ever built, the Avrocar.
The VZ-9 AV Avrocar (often listed as VZ-9) was a Canadian vertical takeoff and landing (VTOL) aircraft developed by Avro Aircraft Ltd. as part of a secret U.S. military project carried out in the early years of the Cold War. The Avrocar intended to exploit the Coandă effect to provide lift and thrust from a single “turborotor” blowing exhaust out the rim of the disk-shaped aircraft to provide anticipated VTOL-like performance. In the air, it would have resembled a flying saucer. Two prototypes were built as “proof-of-concept” test vehicles for a more advanced USAF fighter and also for a U.S. Army tactical combat aircraft requirement.
Avro’s 1956 Project 1794 for the US military designed a larger-scale flying saucer based on the Coandă effect and intended to reach speeds between Mach 3 and Mach 4. Project documents remained classified until 2012.
The effect was also implemented during the U.S. Air Force‘s AMST project. Several aircraft, notably the Boeing YC-14 (the first modern type to exploit the effect), NASA’s Quiet Short-Haul Research Aircraft, and NAL‘s Asuka research aircraft have been built to take advantage of this effect, by mountingturbofans on the top of wing to provide high-speed air even at low flying speeds, but to date only one aircraft has gone into production using this system to a major degree, theAntonov An-72 ‘Coaler’.
An important practical use of the Coandă effect is for inclined hydropower screens, which separate debris, fish, etc., otherwise in the input flow to the turbines. Due to the slope, the debris falls from the screens without mechanical clearing, and due to the wires of the screen optimizing the Coandă effect, the water flows though the screen to the penstocks leading the water to the turbines.
The Coandă effect is used in dual-pattern fluid dispensers in automobile windshield washers.
The operation principle of oscillatory flowmeters also relies on the Coandă phenomenon. The incoming liquid enters a chamber that contains 2 “islands”. Due to the Coandă effect the main stream splits up and goes under one of the islands. This flow then feeds itself back into the main stream making it split up again, but in the direction of the second isle. This process repeats itself as long as the liquid circulates the chamber, resulting in a self-induced oscillation that is directly proportional to the velocity of the liquid and consequently the volume of substance flowing through the meter. A sensor picks up the frequency of this oscillation and transforms it into an analog signal yielding volume passing through.
In air conditioning the Coandă effect is exploited to increase the throw of a ceiling mounted diffuser. Because the Coandă effect causes air discharged from the diffuser to “stick” to the ceiling, it travels farther before dropping for the same discharge velocity than it would if the diffuser was mounted in free air, without the neighbouring ceiling. Lower discharge velocity means lower noise levels and, in the case of variable air volume (VAV) air conditioning systems, permits greater turn-down ratios. Linear diffusers and slot diffusers that present a greater length of contact with the ceiling exhibit greater Coandă effect.
In cardiovascular medicine, the Coandă effect accounts for the separate streams of blood in the fetal right atrium. It also explains why eccentric mitral regurgitation jets are attracted and dispersed along adjacent left atrial wall surfaces (so called “wall-hugging jets” as seen on echocardiographic color-doppler interrogation). This is clinically relevant because the visual area (and thus severity) of these eccentric wall-hugging jets is often underestimated compared to the more readily apparent central jets. In these cases, volumetric methods such as the proximal isovelocity surface area (PISA) method are preferred to quantify the severity of mitral regurgitation.
In meteorology, the Coandă effect theory has also been applied to some air streams flowing out of mountain ranges such as the Carpathian Mountains and Transylvanian Alps, where effects on agriculture and vegetation have been noted. It also appears to be an effect in the Rhone Valley in France and near Big Delta in Alaska.
In Formula One the Coanda effect has been exploited by the McLaren, Sauber, Ferrari and Lotus teams, after the first introduction by Adrian Newey (Red Bull Team) in 2011, to help redirect exhaust gases to run through the rear diffuser with the intention of increasing downforce.
A common misconception is that Coandă effect is demonstrated when a stream of tap water flows over the back of a spoon held lightly in the stream and the spoon is pulled into the stream. While the flow looks very similar to the air flow over the ping pong ball above (if one could see the air flow), the cause is not really the Coandă effect. Here, because it is a flow of water into air, there is little entrainment of the surrounding fluid (the air) into the jet (the stream of water). This particular demonstration is dominated by surface tension.[dubious ]The Coandă effect can be demonstrated by directing a small jet of air upwards at an angle over a ping pong ball. The jet is drawn to the upper surface and curves around, diverting the flow downwards over the back. This change in the momentum of the air flow is reacted out in the reduced pressure on the upper surface of the ball, this suction being sufficient to overcome the weight of the ball (when there is enough air flow). This demonstration can be performed using a vacuum cleaner if the outlet can be attached to the pipe and aimed upwards at an angle.
Another demonstration is to direct the air flow from, e.g., a vacuum cleaner operating in reverse, tangentially past a round cylinder. A waste basket works well. The air flow seems to “wrap around” the cylinder and can be detected at more than 180° from the incoming flow. Under the right conditions, flow rate, weight of the cylinder, smoothness of the surface it sits on, the cylinder will actually move. Note that the cylinder will not move directly into the flow as a misapplication of the Bernoulli effect would predict, but at a diagonal.
The effect can also be seen by placing a can in front of a lit candle. If one blows directly at the can, the air will bend around it and extinguish the candle.
If two lit candles are placed side-by-side, the heated air from each candle rises and entrains surrounding air. Since both “jets” are trying to entrain common air from the space between the two streams, they are drawn towards each other. This is more apparent if the candles are making a little smoke. This is a demonstration of the Coandă effect without the presence of any surface. In some sense, the plane of symmetry between the two flows can be thought of as the surface. In actual fact this is not the Coanda Effect in action but is in fact the Atmospheric Press in action as putting two candles close together causes an area of warmth between them which warms the air which then rises – leaving the cooler atmosphere to try fill this partial void and so the flames are forced together.
The engineering use of Coandă effect has disadvantages as well as advantages.
In marine propulsion, the efficiency of a propeller or thruster can be severely curtailed by the Coandă effect. The force on the vessel generated by a propeller is a function of the speed, volume and direction of the water jet leaving the propeller. Under certain conditions (e.g., when a ship moves through water) the Coandă effect changes the direction of a propeller jet, causing it to follow the shape of the ship’s hull. The side force from a tunnel thruster at the bow of a ship decreases rapidly with forward speed. The side thrust may completely disappear at speeds above about 3 knots.